2005 Volvo S80: common problems and reliability
One of the weaker S80 years.
15 owner complaints, most about fuel/propulsion system. 6 recalls.
Should I buy a 2005 S80?The 2005 Volvo S80 has 15 owner-filed NHTSA complaints and 6 recalls on record. The most-reported areas are fuel/propulsion system and electrical system.
Safety record for the 2005 model year
Source: NHTSA complaints and recalls filed for 2005 Volvo S80 vehicles (US, public record).
The Year Score compares this year with other S80 years only. How we score it
Is 2005 a good year for the S80?
Across the 18 S80 model years we track, complaint volume runs from 1 (2014) to 345 (2000). With 15 complaints, the 2005 S80 sits below the model's median of 24.
These are raw NHTSA complaint totals, not adjusted for how many cars sold or how long each model year has been on the road. Older and higher-selling years accumulate more complaints.
Where owners report problems
Recalls affecting the 2005 S80
air bags:frontal:driver side:inflator module
Campaign 21V766000Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
equipment:electrical:navigational system(global positioning system)
Campaign 10V566000VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
fuel system, gasoline:delivery:fuel pump
Campaign 09V483000VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
electrical system:starter assembly:solenoid
Campaign 05V529000ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Show 2 more recalls
service brakes, hydraulic:foundation components:master cylinder
Campaign 07E023000CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
equipment:other:labels
Campaign 06V375000CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
What owners say across generations
Sentiment is divided by generation and is heavily dependent on maintenance history and specific powertrain.
Owner insights cover all generations of the S80. See the full S80 owner picture and every model year.
Typical used price
Used S80 listings typically run $6,995–$10,990 across 2002 to 2016 model years.
Other S80 model years
Compare every S80 year side by side to see how 2005 ranks against the rest.
Compare the S80 against its rivals
Looking at a specific car?
We're building a full check by VIN: the exact trim and engine, its known problems and recalls, what to inspect, a fair price, and how it compares with its rivals. Get an email when it's ready.
One email when it launches. Unsubscribe any time. Privacy